MATERIAL SAFETY DATA SHEET |
|
Company Name:
|
C.R. LAURENCE CO., INC.
|
|
Address:
|
2503 E. VERNON AVE.
|
|
City / State / Zip:
|
LOS ANGELES / CA / 90058
|
|
US-CHEMTREC Phone(I):
|
(800)424-9300
|
|
US-CHEMTREC Phone(II):
|
(703)527-3887
|
|
CAN-CANUTEC Phone:
|
(613)996-6666
|
|
Vendor Update:
|
9/11/2013
|
|
Date Prepared:
|
9/11/2013
|
|
MSDS Number:
|
RDCRK
;
|
|
|
|
I. CHEMICAL PRODUCT IDENTIFICATION
|
|
Product Name:
|
BACKGLASS HEATER TAB REPAIR KIT - EPOXY
|
|
HMIS Ratings:
|
|
|
Health:
Serious(3)
|
|
|
Flammability:
Slight(1)
|
|
|
Instability/Reactivity:
Slight(1)
|
|
|
Personal Protective Equipment:
B
|
|
NFPA Ratings:
|
|
|
Health:
Serious(3)
|
|
|
Flammability:
Slight(1)
|
|
|
Instability/Reactivity:
Slight(1)
|
|
|
|
II. COMPOSITION, INFORMATION ON INGREDIENTS
|
Chemical
Ingredients |
C.A.S.
Number |
% By
Weight |
ACGIH TLV
TWA/STEL |
OSHA PEL
TWA/STEL |
Other
TWA/STEL |
LD50 |
LC50 |
SILVER (METALLIC)
|
7440-22-4
|
60 - 90
|
0.1 MG/M³
N/A
|
0.01 MG/M³
|
|
N/A
|
N/A
|
| Notes |
|
MODIFIED ALIPHATIC AMINE
|
140-31-8
|
10.0-25.0
|
N/A
N/A
|
N/A
|
|
(RAT) ORAL 2,140 MG/KG; (RBT) DERMAL 880 µL/KG
|
N/A
|
| Notes |
|
|
Other:
|
CANCER INFORMATION: NO INGREDIENTS LISTED AS HUMAN CARCINOGEN BY NTP OR IARC. </BR> REPRODUCTIVE EFFECTS: NONE
MUTAGENIC EFFECTS: NONE
|
|
|
|
III. HAZARDS IDENTIFICATION PRIMARY ROUTE OF ENTRY
|
|
Eyes:
|
THIS PRODUCT MAY CAUSE CHEMICAL BURNS IN THE EYE. DAMAGE IS IRREVERSIBLE.
|
|
Skin:
|
SENSITIZER - MAY CAUSE ALLERGIC SKIN REACTION.
|
|
Ingestion:
|
HARMFUL IF SWALLOWED. MAY CAUSE CHEMICAL IRRITATION IN GASTROINTESTINAL TRACT AND MAY BE POTENTIALLY TOXIC. SILVER INGESTION MAY RESULT IN GENERALIZED ARGYRIA.
|
|
Inhalation:
|
MAY CAUSE RESPIRATORY IRRITATION IF INHALED OVER A LONG PERIOD OF TIME. SENSITIZER- MAY CAUSE ALLERGIC RESPIRATORY REACTION.
|
|
Signs and Symptoms of Exposure:
|
|
|
Medical Conditions Aggravated by Exposure:
|
PRE-EXISTING HEART, LUNG, EYE, SKIN CONDITIONS.
|
|
Other:
|
EMERGENCY OVERVIEW: SILVER/GRAY PASTE WITH AMINE ODOR. THIS PRODUCT IS NON FLAMMABLE. LIQUID MAY CAUSE CHEMICAL BURN IN EYE.
|
|
|
IV. FIRST AID MEASURES
|
|
Eyes:
|
IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER. AFTER INITIAL FLUSHING, REMOVE ANY CONTACT LENSES AND CONTINUE FLUSHING FOR AT LEAST 15 MINUTES. HAVE EYES EXAMINED BY A PHYSICIAN.
|
|
Skin:
|
REMOVE CONTAMINATED CLOTHING AND WASH SKIN WITH SOAP AND WATER. GET MEDICAL ATTENTION IF IRRITATION PERSISTS. WASH CLOTHES SEPARATELY BEFORE REUSE.
|
|
Ingestion:
|
IF SWALLOWED, SEEK MEDICAL ATTENTION. NEUTRALIZE WITH MILK OR DILUTE WITH WATER.
|
|
Inhalation:
|
IN CASE OF EXPOSURE TO HIGH CONCENTRATIONS OF VAPOR OR MIST, REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, GIVE OXYGEN AND CALL A PHYSICIAN. IF BREATHING HAS STOPPED, APPLY ARTIFICIAL RESPIRATION AND CALL A PHYSICIAN.
|
|
|
V. FIRE FIGHTING MEASURES
|
Flash Point:
|
>200°F (>93C) (STETAFLASH)
|
Lower Flammability Limit:
|
N/A
|
Upper Flammability Limit:
|
N/A
|
Extinguishing Agents:
|
USE CARBON DIOXIDE OR DRY CHEMICALS FOR SMALL FIRES, AQUEOUS FOAM OR WATER FOR LARGE FIRES INVOLVING THIS MATERIAL.
|
Fire Fighting Procedures:
|
REMOVE ALL IGNITION SOURCES. CLOSED CONTAINED BREATHING APPARATUS (PRESSURE DEMAND, OSHA/NIOSH APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR.
|
|
|
VI. ACCIDENTAL RELEASE MEASURES
|
Containment/Cleanup:
|
LARGE SPILLS: REMOVE ALL SOURCES OF IGNITION (SPARKS, OPEN FLAMES, ETC). WEAR SELF CONTAINED BREATHING APPARATUS AND APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. VENTILATE AREA AND CONTAIN SPILL WITH INERT MATERIAL. COLLECT SPILL BY SCOOPING UP LIQUIDS AND ABSORBENT MATERIAL AND PLACE IN A CHEMICAL WASTE CONTAINER FOR PROPER DISPOSAL. DO NOT FLUSH TO SEWER. PREVENT MATERIAL FROM ENTERING STORM SEWERS, DITCHES THAT LEAD TO WATERWAYS AND GROUND. </BR> SMALL SPILLS: ABSORB SPILL WITH ABSORBENT MATERIAL, THEN PLACE IN A CHEMICAL WASTE CONTAINER FOR PROPER DISPOSAL.
|
|
|
VII. HANDLING AND STORAGE
|
Other:
|
AVOID PROLONGED OR REPEATED CONTACT WITH SKIN, EYES OR CLOTHING. WASH HANDS BEFORE EATING. USE WITH ADEQUATE VENTILATION. AVOID BREATHING PRODUCT VAPOR. DO NOT REUSE THIS CONTAINER. STORE IN A COOL DRY PLACE, AWAY FROM HEAT, SPARK OR FLAMES. </BR>KEEP OUT OF REACH OF CHILDREN.
|
|
|
VIII. EXPOSURE CONTROLS/PERSONAL PROTECTION
|
Other:
|
WORK HYGENIC PRACTICES: </BR> GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL AIRBORNE LEVELS. LOCAL EXHAUST VENTILATION MAY BE NECESSARY TO CONTROL ANY AIR CONTAMINANTS TO WITHIN THEIR TLV'S DURING THE USE OF THIS PRODUCT. WEAR SAFETY GLASSES WITH SIDE SHIELDS OR GOGGLES AND RUBBER OR OTHER CHEMICALLY RESISTANT GLOVES WHEN HANDLING THIS MATERIAL.
|
|
|
IX. PHYSICAL AND CHEMICAL PROPERTIES
|
|
Appearance:
|
SILVER/GRAY PASTE
|
|
Boiling Point:
|
>400°F (>204C)
|
|
pH:
|
N/A
|
|
Solubility in Water:
|
<10%
|
|
Specific Gravity:
|
2.5-2.8
|
|
Vapor Pressure:
|
<1.0 MM HG @ 20°C
|
|
Vapor Density:
|
>1 (AIR=1)
|
|
Physical State:
|
SILVER/GRAY PASTE
|
Volatile Content:
|
% VOLATILE: <0.5%
|
Other:
|
EVAPORATION RATE: <1 (BUTYL ACETATE = 1)
|
|
|
X. STABILITY AND REACTIVITY
|
Stability:
|
THIS PRODUCT IS STABLE.
|
Hazardous Polymerization:
|
WILL NOT OCCUR.
|
Hazardous Decomposition Products:
|
CARBON MONOXIDE, CARBON DIOXIDE AND OXIDES OF NITROGEN.
|
Incompatible Products:
|
AVOID EPOXY RESINS AND ISOCYANATES, STRONG ACIDS, MINERAL AND ORGANIC ACIDS, STRONG BASES, CAUSTICS AND ALKALI CONTAMINATION.
|
Conditions To Avoid:
|
CONTAMINATION WITH STRONG ACIDS, BASES, EPOXY RESINS OR ISOCYANATES CAN CAUSE POLYMERIZATION.
|
|
|
XI. TOXICOLOGICAL INFORMATION
|
|
|
XII. ECOLOGICAL INFORMATION
|
|
Ecotoxicity:
|
|
|
Persisitence and Degradation:
|
ENVIRONMENTAL IMPACT INFORMATION: </BR> AVOID RUNOFF INTO STORM SEWERS AND DITCHES WHICH LEAD TO WATERWAYS. WATER RUNOFF CAN CAUSE ENVIRONMENTAL DAMAGE. </BR> REPORTING:
U.S. REGULATIONS REQUIRE REPORTING SPILLS OF THIS MATERIAL THAT COULD REACH ANY SURFACE WATERS. THE TOLL FREE NUMBER FOR THE U.S. COAST GUARD NATIONAL RESPONSE CENTER IS: (800) 424-8802.
|
|
|
XIII. DISPOSAL CONSIDERATIONS
|
Disposal Method:
|
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS. WATER RUNOFF CAN CAUSE ENVIRONMENTAL DAMAGE.
|
|
|
XIV. TRANSPORT INFORMATION
|
|
Other:
|
AIR AND GROUND SHIPMENTS: </BR> ADHESIVES, SEALANTS </BR> NOT REGULATED.
|
|
|
XV. REGULATORY INFORMATION
|
TSCA Status:
|
ALL INGREDIENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY.
|
EPA Sara Title III Chemical Listings:
|
THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF THE EMERGENCY PLANNING AND COMMUNITY RIGHT TO KNOW ACT OF 1986 (40 CFR 372).
|
Supplemental State Compliance Information:
|
|
|
Other:
|
WHMIS: CLASS D2B
THIS PRODUCT HAS BEEN CLASSIFIED ACCORDING TO THE HAZARD CRITERIA OF THE CPR AND THE MSDS CONTAINS ALL THE INFORMATION REQUIRED BY THE CPR.
|
|
|
XVI. OTHER INFORMATION
|
|
Other:
|
NORMAL VENTILATION FOR STANDARD MANUFACTURING PRACTICES IS USUALLY ADEQUATE. LOCAL EXHAUST SHOULD BE USED WHEN LARGE AMOUNTS ARE RELEASED.
|
|
|
WARRANTY INFORMATION
|
THIS INFORMATION IS OFFERED IN GOOD FAITH AS TYPICAL VALUES AND NOT AS A PRODUCT SPECIFICATION.
NO WARRANTY, EXPRESSED OR IMPLIED, IS HEREBY MADE. THE RECOMMENDED INDUSTRIAL HYGIENE AND
SAFE HANDLING PROCEDURES ARE BELIEVED TO BE GENERALLY APPLICABLE. HOWEVER, EACH USER SHOULD
REVIEW THESE RECOMMENDATIONS IN THE SPECIFIC CONTEXT OF THE INTENDED USE AND DETERMINE WHETHER
THEY ARE APPROPRIATE.
|